Service Videos

Home » Services » Parts (7)

Timing Belt

Posted October 24, 2017 12:21 PM

Ever heard the sad tale of a staggeringly steep repair bill from a broken timing belt? Bad news. Let's take a lesson from their woes and remember to think about our timing belt.

First, let's review what a timing belt does. The top part of the engine over the cylinders is called the cylinder head. The head contains the valves. There's at least one valve that lets the fresh air into the cylinder. This air, mixed with fuel, burns to create power. Then another valve or two will open to allow the exhaust out of the engine. Each cylinder has 2 to 4 valves - that's 12 to 24 valves for a V-6, up to 32 values on a V-8. The opening and closing of the valves is done by a camshaft. The timing belt uses the rotation of the engine to drive the camshaft which opens and close the valves. It's called a timing belt because it has to be adjusted to rotate the camshaft to keep proper time with the engine so that everything's in sync.

The timing belt is a toothed rubber belt. But some vehicles use a timing chain or timing gears instead of a belt. Timing chains and gears are much more durable, but vehicle manufactures are using belts more because they are quieter - and cheaper. If you have a small or mid-sized passenger car, crossover or mini-van, chances are you have a timing belt.

Unfortunately, timing belts fail without any warning. That shuts your engine down right away. Your pros at George's Wholesale Tire & Auto can inspect your timing belt and look for cracks and looseness. But getting to the belt to take a look can be almost as much work as changing it on some vehicles. That's why manufacturers recommend replacing the belt from time to time. For most vehicles it's from 60,000 to 90,000 miles or 95,000 to 145,000 kilometers. If your owner's manual doesn't specify an interval, ask your service advisor at George's Wholesale Tire & Auto.

Someone we know, who shall remain anonymous, has had two timing belts fail. The first was while he was waiting at a stop light - that repair cost several thousand dollars. The second was while driving on the highway - that one cost more than twice as much. Both had the cars out in the shop for three weeks. His cars had what we call "interference engines," meaning that the valves and pistons are very close to each other. If the timing belt slips even one notch, the pistons will slam into the open valves. That's why our friend's highway failure was so much more - his engine was traveling so fast that the valves were smashed and they chewed up the cylinder head.

A non-interference engine will just shut down if the timing belt breaks. You're stranded, but the engine doesn't suffer permanent damage. In both cases, our hapless friend was just a couple oil changes past the recommended interval for changing the timing belt. This is one of those things that Spring Hill drivers just cannot put off. Now replacing a timing belt is not cheap - but repairs for a broken belt can be far more expensive.

The team at George's Wholesale Tire & Auto recommends Spring Hill drivers check their owners' manual ASAP - especially if you have more than a 60,000 miles or 95,000 kilometers. You may need to get that belt replaced right away. And on many cars, the timing belt drives the water pump. So, it may be a good idea to replace the water pump while you're at it because 90% of the work required for the new pump is already done with the belt change. Doing both at the same time saves you a lot of money because as they say, "timing's everything."

George's Wholesale Tire & Auto
322 Suzanne Avenue
Spring Hill, Florida 34607
(352) 398-1701

 



Serpentine Belt Service at George's Wholesale Tire & Auto in Spring Hill

Posted January 08, 2017 10:01 AM



Don't you hate it when you hear that squeal from under the hood when you're zipping down a busy Spring Hill road? It usually means there is a problem with the serpentine belt. The serpentine belt powers a lot of engine accessories. It runs the alternator - which charges the battery; the water pump - which cools the engine; the air conditioning and the power steering pump. All are pretty important parts. It is called a serpentine belt because it snakes around a bunch of engine components.

Serpentine belts are amazingly tough. They can last for years and go long distances. Like all moving parts, however, they eventually wear out. If your belt breaks while you are driving around Spring Hill, everything will come to a halt within minutes. You need to stop the vehicle immediately or it will overheat, potentially causing engine damage. You can be sure that it won't happen at a convenient time or place. (As if there was a convenient time or place!) You might even need to get your vehicle towed to George's Wholesale Tire & Auto. It's no wonder that vehicle manufacturer's recommend a belt replacement on schedule. It's one of those "have-to's."

Spring Hill drivers who hear a squeal when accelerating, or a slow, slapping sound at idle, should have their serpentine belt looked at. The pros at George's Wholesale Tire & Auto in Spring Hill will visually inspect your belt to see if it needs to be changed sooner than scheduled. If the belt has more than three or four cracks every inch or couple of centimeters, has deep cracks that penetrate half the depth of the belt, is frayed, is missing pieces or has a shiny, glazed look, it needs to be replaced regardless of age or mileage.

Serpentine belt replacement is relatively inexpensive, especially compared with the cost and inconvenience of being stranded or getting a disabled vehicle back to George's Wholesale Tire & Auto for repairs.

You're mom was right: an ounce of prevention really is worth a pound of cure.

George's Wholesale Tire & Auto
322 Suzanne Avenue
Spring Hill, Florida 34607
(352) 398-1701



Have You Checked Your Headlights?

Posted August 28, 2016 08:53 AM



Like everything in the Florida automotive market, there have been great strides in headlight technology in recent years. Florida drivers can be safer at night because of it. Good headlights improve visibility on Spring Hill roads, enabling you to see farther. They also improve your peripheral vision, helping you to see the sides more clearly. The more you can see, the more quickly you can react to road conditions. This is because nearly half of traffic fatalities take place at night. And as Spring Hill resident population ages, everything that helps older eyes is welcome.

Most new vehicles sold in Florida come with halogen headlamps. A decade ago, halogens were exotic and expensive. Now that they are standard equipment, the price has come way down. Many luxury cars are equipped with high intensity discharge, or HID, headlamps. You have probably seen them on some Spring Hill roads; they're very bright and have a bluish tint.

From behind the wheel, there is no doubt that HID headlamps are the best thing going. However, many Spring Hill drivers complain about HID lights in oncoming traffic or when they approach from behind. In fact, when the National Highway Traffic Safety Administration called for public comment, they received a record number of complaints about HIDs. This has lead to several studies - your tax dollars at work. Some expect future regulation of HID lamps.

All halogen headlamps dim over time. Your service advisor at George's Wholesale Tire & Auto recommends that they be changed out once a year. We suggest you replace your headlamps in the fall at the end of Daylight Saving Time. It's easy to remember; when you change your clock, change your headlamps. Remember to replace all headlamps at the same time; then all your lights will be equally bright. You will appreciate it during those long Florida winter nights.

If you have an older vehicle with old-school headlamps, you might be able to get a halogen replacement. You'll be amazed at the difference this upgrade will make.

In addition to regular halogen lamps, Spring Hill vehicles can upgrade to premium lamps that filter some of the yellow light, making a bright white light that's more like natural sunlight. This light's easier on the eyes and should improve reaction time.

Now, you may be able to step up to HID headlamps, depending on the kind of car you drive. These lamps should last the life of your car, but cost several hundred dollars a pair. If you want other Spring Hill vehicles to think you're running HID lamps, you can even buy regular halogens that have a bluish tint. Does she or doesn't she? Only her George's Wholesale Tire & Auto technician knows for sure.

Over time, plastic headlight covers can get cloudy or yellowed. In fact, AAA reports that nine out of ten headlights are dirty or yellowed, greatly reducing vision. In addition to helping you replace your headlamps, many service centers such as George's Wholesale Tire & Auto in Spring Hill, Florida, can restore headlight covers. Headlights can be restored at a fraction of the cost of replacing them.

George's Wholesale Tire & Auto
322 Suzanne Avenue
Spring Hill, Florida 34607
(352) 398-1701



Emergency Items for Your vehicle

Posted July 25, 2016 05:18 AM



Local Spring Hill roadside emergencies can range from a flat tire downtown to being stranded in a snowy ravine for three days. So you may want to consider a basic emergency kit to keep in the car at all times and a travel kit tailored to a specific trip.

Your close-to-home kit for around Spring Hill would have some basic items to work on your car: everything you need to change a tire, gloves, a couple quarts of oil, some antifreeze and water. A can of tire inflator is a great temporary fix for minor flats. You'll also want jumper cables or a booster box, flares, a flashlight and some basic hand tools.

Now for your comfort and safety: a first aid kit, drinkable water, high calorie food (like energy bars), blankets, toilet paper, cell phone, towel, hat and boots. Keep some change for a pay phone, emergency cash and a credit card.

People who live in areas with frequent severe weather or earthquakes may want to carry provisions for longer emergencies.

For trips away from home, consider the weather and geography as you assemble your emergency supplies. You'll need to have a source of light and heat and will want to provide protection against the elements as well as adequate food and water for everyone in the car.

Always tell people where you are going and have a plan for checking in at waypoints. Then if you run into trouble, you can be reported missing as soon as possible and rescuers will be able to narrow the search area.

The key to safe travel is to keep your vehicle properly maintained, plan ahead and let others know your itinerary.

George's Wholesale Tire & Auto
322 Suzanne Avenue
Spring Hill, Florida 34607
(352) 398-1701



Spring Hill Drivers: Is It Time to Replace Your PCV Valve?

Posted October 27, 2015 12:00 PM

The crankcase is the lower part of the engine where the crankshaft is housed and where the engine oil lives. The crankshaft is connected to the pistons that power the engine.


When you are diving around Spring Hill, fuel is burned in your vehicle engine, it pushes the pistons down and the crankshaft rotates and sends power to the transmission. Some of the explosive gases from combustion squeeze past the pistons and down into the crankcase.

Now this gas is about 70% unburned fuel. If it were allowed to remain in the crankcase, it would contaminate the oil and quickly turn it to sludge. Sludge is like Vaseline and clogs passages in the engine, leading to damage.

Also, the pressure build up would blow out seals and gaskets. So in the old days, there was just a hose that vented the crankcase out into the air. Obviously, not good for our air quality in Spring Hill, Florida.

Enter the PCV valve. It's a small, one-way valve that lets out the gases from the crankcase and routes them back into the air intake system where they are re-burned in the engine. Fresh air comes into the crankcase through a breather tube. This makes for good circulation in the crankcase. And that gets the air out. As you can imagine, however, the valve gets gummed up over time.

Your vehicle manufacturer usually recommends they be changed somewhere between 20,000 to 50,000 miles/30,000 to 80,000 kilometers. Unfortunately, PCV valve replacement is left out of some vehicle owner's manuals, but your friendly service advisor at George's Wholesale Tire & Auto, we will make sure your PVC is replaced if needed.

George's Wholesale Tire & Auto
322 Suzanne Avenue
Spring Hill, Florida 34607
(352) 398-1701



Timing Belt Replacement in Spring Hill

Posted April 24, 2015 12:00 PM

Today we want to talk to Spring Hill drivers about timing belts. They're something that many drivers don't know much about and yet your vehicle won't run if it's broken – and it could cause many thousands of dollars damage if it does break. A broken timing belt is usually a tale of woe. Even though timing belt replacement is scheduled in the owner's manual, it's not the kind of thing that most Spring Hill area auto owners remember because it's not well understood.

Let's review what a timing belt does. As most know, the engine's power is generated in the cylinders. A piston rides up and down in the cylinder. During the first down stroke, an intake valve at the top of the cylinder opens and air and fuel is drawn into the cylinder. Then the piston returns to the top, compressing the fuel and air mix. At the top, the spark plug fires, igniting the fuel, pushing the piston down in the power stroke. As the piston once again returns up in the final stroke of the cycle, an exhaust valve opens at the top of the cylinder and the exhaust is pushed out. The timing belt is what coordinates the opening and closing of the intake and exhaust valves. It's called a timing belt because the valves have to open and close at just the right time.

Now, not all vehicles have timing belts. Some have timing chains. Like the name implies, they use a chain rather than a belt to perform the function. It used to be that most engines used timing chains, which are extremely durable. The leading vehicle manufactures started using belts rather than chains to save money in the manufacturing process. So now Spring Hill drivers and their advisors at George's Wholesale Tire & Auto are left with a component that can break. They sort of shifted the problem to us. There are two broad categories of engine design: interference and non-interference. If the timing belt on a non-interference engine breaks, the engine simply stops running. That could be very dangerous for drivers depending on where they are at the time, but it causes no internal engine damage.

Interference vehicle engines, on the other hand, will get real messed up when the timing belt breaks, because the valves will actually fall down into the path of the pistons. Things get chewed up when that happens and it'll cost a chunk of change to repair the vehicle engine.

So, what are the warning signs? Unfortunately, there really aren't any. There aren't tell-tale sounds. In some vehicles, a technician from George's Wholesale Tire & Auto may be able to see part of the belt for a visual inspection, but many have a cover that's in the way. The reality is that if the belt slips even one notch, it might as well be broken for all the damage it'll cause. There's no middle ground.

So how can we avoid these problems? Simply replace the timing belt when your owner's manual calls for it. It can be 60,000 miles/97,000 km; it might be 90,000 or 100,000 miles/145,000 or 160,000 km. The point is, if you have 60,000 or more miles (97,000 or more km), ask your George's Wholesale Tire & Auto service advisor right away if your vehicle requires a timing belt replacement.

Contact George's Wholesale Tire & Auto to learn more about your car's timing belt
You can find us at:

322 Suzanne Avenue
Spring Hill, Florida 34607
(352) 398-1701

Sometimes Spring Hill drivers can go quite a while without a failure, but we've seen them happen within a couple of oil changes of being due. It's not worth the risk.

What does it cost to replace a timing belt in Spring Hill? Well, that really depends on what kind of car you have. I can tell you that it's usually not very easy to get to the timing belt – you often have to remove some accessories to get at it. It isn't a cheap procedure, but it's a fraction of what it could cost to repair the damage caused by a failure.

At George's Wholesale Tire & Auto in Spring Hill, we're all about trying to prevent repairs, keeping you and your passengers safe and increasing your driving enjoyment. 



PCV Valve Replacement

Posted July 15, 2014 12:00 PM



Hello Spring Hill, let's talk about your often-unnoticed but extremely important PCV valve. The energy from exploding fuel is what powers your engine. But some of the vapors from the explosions escape into the lower part of the engine, called the crankcase. The crankcase is where your engine oil hangs out. These gases are about 70% unburned fuel. If the gases were allowed to stay in the crankcase, they would quickly contaminate the oil and turn it to sludge. Spring Hill folks know that sludge is one of the biggest enemies of your engine, clogging it up and eventually leading to expensive failures. Also, the pressure buildup would cause seals and gaskets to blow out. Therefore, these gases need to be vented out.

Pre-1963, gasoline engines had a hose that let the  fumes vent out into the air. In 1963, the federal government required gas engines to have a special one-way valve installed to help reduce dangerous emissions. (Can you imagine how polluted our Florida air would be if every car had been releasing those poisonous fumes for the last 50 years?) Diesel engines are not required to have these valves.

The positive crankcase ventilation (PCV) valve routes crankcase gases through a hose and back into the air intake system where they are re-burned in the engine. Fresh, clean air is brought into the crankcase through a breather tube. It's really a pretty simple system, but it does the job. The re-circulating air removes moisture and combustion waste from the crankcase, preventing sludge. This extends not only the life of your oil but the engine as well. The PCV relieves pressure in the crankcase, preventing  oil leaks.


Eventually, the PCV valve can get gummed up. Then it can't move enough air through the engine to keep it working properly for Spring Hill vehicles. If the PCV valve is sticking enough, you could have oil leaks, excess oil consumption and a fouled intake system. If you experience hesitation,  surging or an oil leak, it may be a sign of PCV valve problems. Your vehicle's owner's manual may give a recommendation for when the PCV valve should be replaced - usually between 20,000 mi/32,000 km and 50,000 mi/80,000 km. Unfortunately, some don't list a recommendation in the manual, so it can be easy to overlook.


Many PCV system problems can be diagnosed by our technicians at George's Wholesale Tire & Auto . Fortunately, PCV valve replacement is both quick and inexpensive at George's Wholesale Tire & Auto. Proper oil changes will greatly extend the life of the PCV valve. Skipping a few recommended oil changes can allow varnish and gum to build up in the valve, reducing its efficiency. So now when your Spring Hill service technician tells you its time to replace your PCV valve, you will know what he's talking about. If you have had your car for a while and this is the first you've ever heard of a PCV valve, ask your technician to check yours out or call George's Wholesale Tire & Auto at (352) 398-1701.

George's Wholesale Tire & Auto
322 Suzanne Avenue
Spring Hill, Florida 34607
(352) 398-1701



Click HERE to request services!

Air Conditioning
Air Conditioning
Batteries
Batteries
Belts
Belts
Brakes
Brakes
Computerized Alignment
Computerized Alignment
Cooling System Maintenance
Cooling System Maintenance
CV & Drive Axle
CV & Drive Axle
Exhaust
Exhaust
Front End
Front End
Nitrogen
Nitrogen
Oil Change
Oil Change
Radiator
Radiator
Scheduled Maintenance
Scheduled Maintenance
Shocks and Struts
Shocks and Struts
Tire Repair
Tire Repair
Tire Rotation
Tire Rotation
Transmission Maintenance
Transmission Maintenance
Tune-Ups
Tune-Ups
Wheel Balance
Wheel Balance